Product ID:WELD-ON P-70 PRIMER FOR PVC PLASTIC PIPE
MSDS Date:01/01/1987
FSC:8010
NIIN:00N003418
MSDS Number: BCJYJ

INDUSTRIAL POLYCHEMICAL SERVICE

17109 S MAIN
GARDENA, CA 90247
US

Cage: 17510

IPS CORPORATION

379 GARDENA, CA 90248 US

Telephone: 310-898-3300

Cage: 17510

TETRAHYDROFURAN (SARA III)

CAS: 109-99-9

RTECS: LU5950000

OSHA PEL 200 PPM/250 STEL

ACGIH TLV: 200 PPM/250STEL;9192

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 200 PPM/300 STEL

ACGIH TLV: 200 PPM/300STEL 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

DIMETHYLFORMAMIDE

CAS: 68-12-2

RTECS: LQ2100000

OSHA PEL S, 10 PPM

ACGIH TLV: S, 10 PPM; 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

CYCLOHEXANONE (SARA III)

CAS: 108-94-1

RTECS: GW1050000

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Effects of Overexposure:SEVERE OVEREXPOS: NAUS,DIZZ,HDCH,NARCOS,IRRIT
OF EYE/NASAL PASSAGES/SKIN. (SEE SUP DATA)

First Aid:INHAL: REMOVE TO FRESH AIR,GIVE ARTIF RESP IF NEC. SKIN: WASH
W/ PLENTY OF WATER REMOVE CONTAMINATED CLOTHING & WASH BEFORE
REUSE. EYE: FLUSH W/ WATER FOR 15 MIN & CALL DOCTOR. INGEST: DO NOT
INDUCE V OMIT. CALL DOCTOR IMMED.

Flash Point:6F TCC
Lower Limits:2
Upper Limits:11.8
Extinguishing Media:DRY CHEM,CO*2,FOAM-ANSUL"PURPLE"-NATIONAL
AER-O-FOAM,FOG
Fire Fighting Procedures:EVAC ENCLSD AREAS.STAY UPWIND.WEAR SCBA-POS
PRESS (SUPP DATA
Unusual Fire/Explosion Hazard:FIRE HAZARD BECAUSE OF LOW FLASH PT & HI
VOLATILITY.VAP HEAVIER THAN AIR-MAY TRAVEL TO IGNIT SOURCE.

Spill Release Procedures:ELIMINATE ALL IGNIT SOURCES.AVOID BRTH
VAPORS.KEEP LIQ OUT OF EYES.FLUSH W/LARGE VOLUME OF WATER.CONTAIN
LIQ W/SAND OR EARTH.ABSORB W/SAND OR NONFLAM ABSORBENT MATERIAL &
TRANSFER INTO STEEL FOR RECOV ERY/DISPOSAL.PREVENT LIQ FROM
ENTERING DRAINS.

Handling and Storage Precautions:ALL HANDLING EQUIP SHOULD BE
ELECTRICALLY GROUND. STORE BETWEEN 40F-110F.
Other Precautions:KEEP AWAY FROM HEAT. SPARKS & OPEN FLAMES. AVOID
PROLONGED BREATHING OF VAPORS. USE ADEQUATE VENTILATION. AVOID SKIN
CONTACT.

Respiratory Protection:NIOSH/MSHA APPRVD RESPIRATOR FOR ORGANIC VAPOR
IN CONFINED AREA-MFR.
Ventilation:LOCAL-PREFERABLE. GENERAL-LOW POINT-MIN OF 6 AIR
CHNGES/HOUR
Protective Gloves:RUBBER/PVA
Eye Protection:CHEM SAFETY GOGGLES
Other Protective Equipment:IMPERVIOUS APRON
Supplemental Safety and Health
FIRE FIGHTING:USE WATER SPRAY TO COOL CONTAINERS,FLUSH SPILLS FROM
SOURCES OF IGNIT & DISPERSE VAP.OVEREXPOS:CUMULATIVE INJURY IF RTPD
ABSORB BY SKIN IN SUFFICIENT QUANITIES;DEFAT TISSUE.

Boiling Pt:B.P. Text:151F;66C
Vapor Pres:190
Vapor Density:2.49
Spec Gravity:0.870
Evaporation Rate & Reference:5.5-8 (BUAC=1)
Solubility in Water:COMPLETE
Appearance and Odor:CLEAR OR PURPLE COLOR-ETHERAL ODOR
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
CAUSTICS,AMMONIA,INORG ACIDS,CHLORINATED CMPDS (SEE SUP DATA
Stability Condition to Avoid:KEEP AWAY FROM HEAT,SPARKS,OPEN
FLAME,OTHER IGNIT SOURCES.
Hazardous Decomposition Products:HYDROGEN DIOXIDE,HYDROGEN
MONOXIDE,CO,CO*2,VARIOUS HYDRCRBNS
Conditions to Avoid Polymerization:KEEP AWAY FROM HEAT,SPARKS,OPEN
FLAME & OTHER IGNIT SOURCES.

Waste Disposal Methods:FOLLOW LOCAL,STATE & FEDERAL REGULATIONS.
CONSULT DISPOSAL EXPERT. CAN BE DISPOSED OF BY INCINERATION.
EXCESSIVE QUANTITIES SHOULD NOT BE PERMITTED TO ENTER DRAINS. WASTE
CODE: 412.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.